Search results

The impeller for the Johnson pump is NOT the same as the Jabsco. The Jabsco impeller is about 1mm taller than the Johnson, and will be too tight causing wear on the end plates in the pump. I found that even with the Johnson impeller, I was replacing the cover plate due to wear every couple of...

I just checked my Washington State title, and it shows an 11 digit number. I remembered that I have a photo of the HIN number, and checked it. The actual number on the boat is 12 digits + 2 letters. So I don't have to change the HIN, but it looks like I need to get the title straightened...

psneeld, R & R is estimated at $6k, the boat is already in an Everett yard, and the move and storage indoors is included in the $6k. Nomad Willy, That FL 120 price has been going up every year, but $17k does seem high. Harbor Marine has good prices on most stuff, but you have to compare...

Thanks to all who posted on this thread. My friend has decided to have the current FL 120 engines remanufactured by Harbor Marine, Everett, WA. Reasons include, low compression on three cyls, the oil leaks, need to rebuild one transmission (not a Velvet Drive) possible leaking head gasket...

A friend of mine has a twin engine 42ft trawler. Both Ford Lehman 120hp engines need an overhaul. The prices quoted to remove, overhaul, and reinstall are running $30k to $50k. Has anyone replaced the FL 120 with a new different engine? What engines are suitable? I have heard that John...

You could contact Wefing's Marine. They are a dealer for Rosborough and may have the info you want. Link Wefing's Marine - Simply The Best If you get the photo or video, could you post it here? I am considering a Rosborough and I too question the space in the head compartment.

Nightsky, I set an alarm when operating my trawler if I feel drowsy. My iPhone has a countdown timer which I set to 5 min. The phone is on the dash near the helm. i usually reset the timer prior to the alarm sounding, but if i drowse, it will wake me. The time can be set to a suitable...

If you are cruising in the Puget sound, San Juans or Gulf Islands-Victoria or Vancouver areas, there are pumpouts available. If in the remote areas of BC, pumping over the side is legal and required, as pumpouts are few and far between. BC has restricted areas, where no discharge is allowed...

GANDK2PNW, If you are planning on living aboard full time in the PNW your boat needs to have: 1. The ability to heat itself not using shore power (electricity). A diesel furnace is likely the best choice. Heating in the winter can use several gallons (3-5+) of diesel daily. 2. Comfortable...

For expert advice from a factory authorized repair center, contact Mike, in the service dept at: Harbor Marine 1032 W Marine View Dr Everett, WA 98201 425-259-3285 I have been told that water in the trans fluid comes from the trans oil cooler, and the cooler should be replaced ASAP. I also...

Arch, Many thanks for the details. You have done a great job.

The state of Washington has a provision to allow an out of state buyer to purchase a vessel and keep and use it in Washington without paying Washington sales tax. I think the period is up to 180 days, but a buyer should find out from a boat broker. This may be the section of the tax law that...

Arch, Firefly, Thanks for your replys. I had figured out most of my solar installation plans, but these details help a lot. Arch, Do you have a photo showing how you mounted the lower ends of the arches?

Firefly, Good point. Do you think the set screws would eventually cut in as much as they will, and become stable?

Arch, That's great detail. Any further detail photos would be greatly appreciated. Is the t-bar about 1 inch by 1 inch by 1/4in thick? Where did you install the controllers?

Arch, That is a beautiful job. You could use Loc-tite on the setscrews. Do you have any detail photos of the clamps and t-bar installed to the tubes? I am going to put solar on my boat (37ft Puget Trawler) this year. Your boat looks to be a Tiawan cousin to mine.

I have not had good experiences with Rule switches lately. I purchased two packages of a Rule 800 bilge pump and a switch (the cheaper Rule switch) from Amazon. I have the same switch in my trawler which was installed by the PO and has worked for over 10 years. The first switch failed after...

I have used the Securite call several times in BC, Canada waters. There are several narrow, sometimes blind current passes where you cannot see oncoming traffic. Typical warning, 'Securite, Securite, Securite, 40 foot power boat eastbound thru Jackson Narrows, any opposing traffic respond on...

I am having a problem with Rule bilge pump switches. I purchased two packages of a Rule 800 bilge pump and a switch (the cheaper Rule switch) from Amazon. I have the same switch in my trawler which was installed by the PO and has worked for over 10 years. The first switch failed after one...

Thanks to everyone who posted on this thread. I have gotten a lot of good info, and found a very local source, Platt Electric. While chasing links, I have found several solar companies in my local area. Thanks to Steve D, I now know about the WA state solar sales tax exemption. I hope to...

Here is a link to a blog about a 1974 Delta 50. Datawake Historical Photos - Circa 1976 - Technomadic & Gonzo EngineeringTechnomadic & Gonzo Engineering

I have decided to install solar power on my 37ft Puget Trawler. Does anyone have a recommendation for a company the sells the panels and controllers? Preferred area is Seattle north to Bellingham. Any recommendation for panel or controller brands would also be appreciated. I think I want...

Another possibility is that the coupler is worn out. If the engine has been out of alignment for any length of time the two parts of the coupler can wear. I had to replace my shaft and coupler at 5200 hours on my Tiawan trawler with a Lehman 120 in it. The new coulper and shaft had to be...

Try a Google search on 'what is us.u.openx.net'. This search shows a couple of sites that purport to explain how to remove openx.net. Also says openx.net is a malware/virus server.

Trawlerforum members, I have put him on my 'never, ever do business with him' list.