|
10-14-2016, 10:49 AM
|
#1
|
Senior Member
City: La Paz, BCS
Vessel Name: Ansedonia
Vessel Model: Californian/Carver 52CPMY
Join Date: Dec 2014
Posts: 379
|
Smoke in the Cabin
Hi folks,
I was just down in La Paz for a short week of projects aboard Harmony. Well, one morning I was listening to the morning net and enjoying my coffee, when I noticed a light haze of smoke and the smell of electrical insulation burning. Yikes!
I quickly grabbed a flashlight and began a methodical search of the boat. No obvious causes were found in the main cabin and forward and aft staterooms, so I headed into the engine room, where the smoke was a bit thicker. I checked the AC cooling pump, as it had been running since I came on board, but that wasn't it.
I found the problem to be my main freshwater pump. It is a 5gpm automatic pump that used to be sold by WM. The problem was that the sealed pressure switch somehow had some water leak in and short it out. The switch is in the center of the end shot of the pump. I am including the model # and other info in the pictures just as a FYI for those of you who might have the same pump.
Luckily, I was comfortably tied to the dock, and not underway at night in stormy seas. I was able to swap out the pump with a similar spare carried onboard, and I ordered a new replacement, to be delivered and installed on my next trip down.
I also discovered that my 2 gal accumulator had developed several small rust holes/leaks, so I ordered a new one of those also. Strangely, none of my smoke detectors had gone off yet. Maybe I found the problem early?
Anyway, just sharing my experience.
Cheers, Bill
__________________
"There is simply nothing more worth while than messing around in boats."
|
|
|
10-14-2016, 12:33 PM
|
#2
|
Guru
City: Satsuma FL
Vessel Name: No Mo Trawla
Vessel Model: Hurricane SS188
Join Date: Jul 2014
Posts: 2,300
|
Quote:
Originally Posted by Montenido
Strangely, none of my smoke detectors had gone off yet. Maybe I found the problem early?
|
Maybe you found your smoke detectors had exceeded their useful life. 10 years is supposed to be the end of use date for the sensors.
|
|
|
10-14-2016, 12:37 PM
|
#3
|
Guru
City: Ft Pierce
Vessel Name: Sold
Vessel Model: Was an Albin/PSN 40
Join Date: Oct 2011
Posts: 28,119
|
You can usually smell things or see smoke long before the detectors go off.
The minute a pan starts smoking in the galley doesn't mean the detectors go off at that instant.
Asleep...all bets off...especially depending on sleeping quarters.
I once had a 14 ga wire brown about an inch long...just browned....it was to the helicopter landing gear and it caused so much smoke I lost sight of the copilot just 4 feet away. Amazing how much smoke us produced in such a short amount of time and so little oxidation of the fuel.
|
|
|
10-14-2016, 01:01 PM
|
#4
|
Guru
City: Seaford Va on Poquoson River, VA
Vessel Name: Old Glory
Vessel Model: 1970 Egg Harbor 37 extended salon model
Join Date: Jan 2016
Posts: 2,264
|
So the wires develop a short get overheated and burn.
What is the amp draw on the pump, what is the breaker rating? Is you OCP device too high of a value? Wires too small? From the pic, says use a 15 amp fuse, motor draws 11.2 amps max.
|
|
|
10-14-2016, 01:01 PM
|
#5
|
Guru
City: Gulf Shores, Ala.
Vessel Name: Ulysses
Vessel Model: Romsdal 1963
Join Date: May 2013
Posts: 878
|
If I am not mistaken you are using an "on demand" pump. Which means that it runs when it senses a demand. No accumulator tank is needed and often if one is used it interferes with the pumps designed cut/in cut/out characteristics. Especially if there is a minor leak in the Accumulator tank. The pump will continuously run at very slow speed. That may have been the original problem and not water on the switch. You should also fuse the line in to the pump if not already.
|
|
|
10-14-2016, 04:01 PM
|
#6
|
Guru
City: .
Join Date: Aug 2016
Posts: 437
|
@Montenido
If I may give you a personal tip which tops my security list aboard :
At the dock In the event of smoke or a smell of smoke, immediately shut off the power AC & DC, then and only then, investigate.
P.
|
|
|
10-14-2016, 04:34 PM
|
#7
|
Guru
City: Coupeville Wa.
Vessel Name: Pacific Myst
Vessel Model: West Bay 4500
Join Date: Oct 2015
Posts: 2,402
|
Pilou is correct
Quote:
At the dock In the event of smoke or a smell of smoke, immediately shut off the power AC & DC, then and only then, investigate.
|
Absolutely the first thing to do in any fire, especially an electrical fire is kill all the circuits. Dockside you can kill everything with your main breaker(s) and master switche(s).
At sea kill all non-essential circuits. In calm weather that would be everything.
Montenido, be careful
Quote:
....so I headed into the engine room, where the smoke was a bit thicker.
|
When entering a suspect space do it very carefully. Feel the surface of the door / hatch with the back of your hand. If you have a dogged opening crack the dogs enough for a small gap and check again. Introducing fresh air to a fire can be very dangerous.
|
|
|
|
Thread Tools |
Search this Thread |
|
|
Display Modes |
Linear Mode
|
Posting Rules
|
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts
HTML code is Off
|
|
|
|
» Trawler Discussions |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|